Auto ignition coil manufacturer with Hj-auto: Single ignition coils or also called plug well ignition coils are plugged directly onto the spark plug in the spark plug well. This means that each spark plug has its own ignition coil, which is controlled directly by the engine control unit. A modern ignition coil just looks like a rubber boot that slips onto its spark plug. Up top, there’s an electrical connector for receiving voltage and some threads to mount it securely on the engine. If you were to dissect the component, however, you would find several meters of tightly wound copper wiring that make up the coil pack. These are wrapped around an iron core which receives the 12V current to serve as an electromagnet. The energy stored in the magnetic field of the core is the energy that is transferred to the spark plug. Lastly, the whole coil pack is embedded in a resin insulator to prevent short-circuiting. The ignition coil uses a principle known as Faraday’s law of induction to produce incredible amounts of power, and the same law applies when constructing electric motors as well as generators. Read additional info at ignition coil suppliers.
These multiple-coil-pack-systems are much more reliable than the distributors of the past, but individual ignition coils can still fail over time and lead to an engine misfire condition. When a cylinder misfires, that means the fuel inside it is not burning at the correct time or not burning at all. This is also sometimes referred to as a dead cylinder. Prolonged misfiring can lead to larger problems like warped piston rods or corrosion inside the cylinder wall. It can also cause unburned fuel to leak into your exhaust system, which is bad for the environment and worse for your car’s catalytic converters. Once identified, a misfire should be addressed as soon as possible.
The car coil itself is a transformer, which is like a transformer in a household appliance. When the voltage changes within a specified range, the transformer will not be burned. Usually, the burning of the transformer occurs when the transformer is overloaded. When solving this problem, we must try to find out the cause of the excessive load or the aging of the components. If there is no fire or weak sparks that suddenly occur during driving, an infrared thermometer or hand touch can be used to determine whether the car coil or the ignition module has an internal short circuit or open circuit fault. When the fault is judged, it can also be restarted. Haiyan ignition coil manufacturer has many offices in other countries. One of the larger productive enterprises.
By using the effects of mutual inductance and by using a secondary winding that has 100 times more windings than the primary winding, it is therefore possible to transform the original 12-volt supply into a very high voltage. This process of changing a low voltage into a high voltage is referred to as the ‘transformer action’. In an ignition coil, the primary and secondary windings are wrapped around an iron core, which helps concentrate and enhance the strength of the magnetic field and flux, thus making the ignition coil more efficient.
Using a changing magnetic field to induce an electric current: If a coil of wire is exposed to a magnetic field and the magnetic field then changes (or moves), it creates an electric current in the coil of wire. This process is known as ‘inductance’. This can be demonstrated simply by moving a permanent magnet across a coil. The movement or change in the magnetic field or magnetic flux induces an electric current into the coil wire. There are two main factors that affect how much voltage is induced into the coil: The faster the change (or speed of movement) of the magnetic field and the greater the change in the strength of the magnetic field, the greater the induced voltage. The greater the number of windings in the coil, the greater the induced voltage.
Haiyan ignition coil suppliers produce a number of different product series, including car coil, tool cabinets and hardware accessories. The products of Haiyan ignition coil wholesale suppliers have the following advantages: well-chosen materials, reasonable design, stable performance, excellent quality, and affordable price. Such a product is up to customers’ needs for a highly cost-effective product. Haiyan is a ignition coil suppliers and car coil company which have created a number of successful series, and car coil are one of them. Read extra info at hj-auto.com.
Haiyan car ignition coil suppliers have 200 workers, around 170 work over 4 years, with an independent long-term workflow and productivity, have one department including 30 products technology development and research. Our automotive ignition coil manufacturers cover over 14000 square meters, have been awarded city contracts and keeping promises to units, also we certify ISO9001, and TS16949 for a quality system, truly achieving the quality first, reputation first quality service for our customers at home and abroad. Kindly welcome domestic and overseas patrons to come and guide.